Please wait a minute...
 首页  期刊介绍 期刊订阅 联系我们 横山亮次奖 百年刊庆
 
最新录用  |  预出版  |  当期目录  |  过刊浏览  |  阅读排行  |  下载排行  |  引用排行  |  横山亮次奖  |  百年刊庆
清华大学学报(自然科学版)  2018, Vol. 58 Issue (3): 330-336    DOI: 10.16511/j.cnki.qhdxxb.2018.21.005
  核能与新能源工程 本期目录 | 过刊浏览 | 高级检索 |
基于FPGA的数字化电涡流位移传感器设计
于金鹏, 周燕, 莫逆, 刘兴男, 赵雷
清华大学 核能与新能源技术研究院, 北京 100084
Design of a digital eddy current displacement sensor based on FPGA
YU Jinpeng, ZHOU Yan, MO Ni, LIU Xingnan, ZHAO Lei
Institute of Nuclear and New Energy Technology, Tsinghua University, Beijing 100084, China
全文: PDF(2133 KB)  
输出: BibTeX | EndNote (RIS)      
摘要 电涡流位移传感器的载波信号和解调信号均为模拟处理信号,其测量和解调电路均会提高硬件电路复杂性和信号的不稳定性,并增大磁轴承系统的总体设计体积和功耗等。针对这一问题,该文设计了以调幅式电涡流位移传感器为基础的数字化电涡流位移传感器。利用现场可编程门阵列(FPGA)的数字输出信号设计传感器的载波信号,通过FPGA的软件设计对测量电路的输出信号进行数字化处理。该设计在有效降低电路设计复杂性和功耗的同时,提高了传感器测量的可靠性和精确性。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
于金鹏
周燕
莫逆
刘兴男
赵雷
关键词 电涡流位移传感器现场可编程门阵列(FPGA)载波信号数字解调    
Abstract:The carrier and demodulated signals of eddy current displacement sensors are both analog signals. Thus, the measurement and demodulation circuitries are complex, unstable and increase the volume and power consumption of the magnetic bearing system. This paper describes an improved digital eddy current displacement sensor based on amplitude modulation with the digital carrier signal given by a field programmable gate array (FPGA) to demodulate the digital output signal of the sensor. The measurement reliability and accuracy are improved while the complexity and power consumption are reduced in this integrated digital eddy current displacement sensor.
Key wordseddy current displacement sensor    field programmable gate array (FPGA)    carrier signal    digital demodulation
收稿日期: 2017-10-14      出版日期: 2018-03-15
ZTFLH:  TP212.1  
基金资助:国家科技重大专项(2011ZX06901-010)
通讯作者: 赵雷,研究员,E-mail:zhaolei@.tsinghua.edu.cn     E-mail: zhaolei@.tsinghua.edu.cn
作者简介: 于金鹏(1992-),男,博士研究生。
引用本文:   
于金鹏, 周燕, 莫逆, 刘兴男, 赵雷. 基于FPGA的数字化电涡流位移传感器设计[J]. 清华大学学报(自然科学版), 2018, 58(3): 330-336.
YU Jinpeng, ZHOU Yan, MO Ni, LIU Xingnan, ZHAO Lei. Design of a digital eddy current displacement sensor based on FPGA. Journal of Tsinghua University(Science and Technology), 2018, 58(3): 330-336.
链接本文:  
http://jst.tsinghuajournals.com/CN/10.16511/j.cnki.qhdxxb.2018.21.005  或          http://jst.tsinghuajournals.com/CN/Y2018/V58/I3/330
  图1 原始传感器测量电路设计
  图2 基于FPGA 数字解调传感器设计
  图3 载波源为滤波方波的差动电路结构图
  图4 差动测量电路
  图5 数字信号处理设计
  图6 倍压包络检波
  图7 极值区间判断
  图8 滑动平均滤波
  图9 传感器的制备
  图10 测量台架与实验电路板
  图11 数字方波信号的处理
  图12 差动输出信号
  图13 SignalTapII模块采集数据
  图14 滤波输出电压与位移
  图15 不同间隙下的测量输出电压
[1] DEVER T P, PALAZZOLO A B, THOMAS Ⅲ E M, et al. Evaluation and improvement of eddy current position sensors in magnetically suspended flywheel systems[R]. Hanover, MD:NASA, 2001.
[2] 王海英, 李文龙, 崔玥, 等. 基于电涡流传感器的智能高度控制系统设计[J]. 控制工程, 2008, 15(1):43-45, 49. WANG H Y, LI W L, CUI Y, et al. Design of intelligent height control system based on eddy current sensor[J]. Control Engineering of China, 2008, 15(1):43-45, 49. (in Chinese)
[3] 邓志鹏, 陈向东. 石英晶体振荡器的微处理器温度补偿技术研究[J]. 单片机与嵌入式系统应用, 2012, 12(8):4-7. DENG Z P, CHEN X D. Research of microprocessor temperature compensation technique for quartz crystal oscillator[J]. Microcontrollers & Embedded Systems, 2012, 12(8):4-7. (in Chinese)
[4] 黄庆彩, 祖静, 裴东兴. 基于MAX038的函数信号发生器的设计[J]. 仪器仪表学报, 2004, 25(S1):321-322. HUANG Q C, ZU J, PEI D X. Signal generator design with integrated circuit MAX038[J]. Chinese Journal of Scientific Instrument, 2004, 25(S1):321-322. (in Chinese)
[5] LI L C. Eddy-current displacement sensing using switching drive where baseband sensor output is readily available[J]. IEEE Transactions on Instrumentation and Measurement, 2008, 57(11):2548-2553.
[6] RODRIGUEZ S, WANG Y X, AKID R, et al. Design of an FPGA-based eddy current instrument for the detection of corrosion pits[C]//Proceedings of 2015 IEEE International Instrumentation and Measurement Technology Conference. Pisa, Italy:IEEE, 2015:705-710.
[7] 董永贵, 孟凡, 张琦. 电涡流传感器的脉冲激励与双参数检测[J]. 仪表技术与传感器, 2009(S1):221-224. DONG Y G, MENG F, ZHANG Q. Pulsed excitation and dual-parameter measurement method for eddy current sensor[J]. Instrument Technique and Sensor, 2009(S1):221-224. (in Chinese)
[8] PASSENBRUNNER J, SILBER S, AMRHEIN W. Investigation of a digital eddy current sensor[C]//Proceedings of 2015 IEEE International Electric Machines & Drives Conference. Coeur d'Alene, USA:IEEE, 2016:728-734.
[9] FEKRI A, NABAVI M, RADELJIC'-JAKIC' N, et al. An eddy-current displacement-to-digital converter based on a ratio-metric delta-sigma ADC[C]//Proceedings of the 40th European Solid State Circuits Conference. Venice Lido, Italy:IEEE, 2014:403-406.
[10] 庞喜浪, 刘刚, 文通. 用于磁轴承位移检测的数字式电涡流位移传感器设计与实验研究[J]. 传感技术学报, 2011, 24(3):360-364. PANG X L, LIU G, WEN T. Design and experiment study of digital eddy current displacement sensor used for displacement detection of magnetic bearing[J]. Chinese Journal of Sensors and Actuators, 2011, 24(3):360-364. (in Chinese)
[11] 李移. 数字式电涡流位移传感器的研制[D]. 西安:西安科技大学, 2013. LI Y. The development of the digital eddy current displacement sensor[D]. Xi'an, China:Xi'an University of Science and Technology, 2013. (in Chinese)
[12] 杨剑, 刘光斌. 单片机系统中应用的几种数字滤波方式[J]. 微计算机应用, 2006, 27(1):114-116. YANG J, LIU G B. Several ways of digital filtering application in MCU system[J]. Microcomputer Applications, 2006, 27(1):114-116. (in Chinese)
[1] 周斌, 邱志昌. 用于MEMS陀螺的PCIe实时测控平台设计[J]. 清华大学学报(自然科学版), 2017, 57(12): 1310-1316.
[2] 彭卓, 邓焱, 马骋, 熊剑平, 尹永利. 基于FPGA的高精度正弦信号发生器设计与实现[J]. 清华大学学报(自然科学版), 2014, 54(2): 197-201.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
版权所有 © 《清华大学学报(自然科学版)》编辑部
本系统由北京玛格泰克科技发展有限公司设计开发 技术支持:support@magtech.com.cn