Solid-gas products and reaction mechanism of pyrolysis of the sheath material of a typical flame-retardant low-voltage cable in substations during a fire

ZHANG Jiaqing; GUO Yi; FENG Rui; LI Kaiyuan; HUANG Yubiao; SHANG Fengju

doi:10.16511/j.cnki.qhdxxb.2021.25.010

PDF(5050 KB)

Journal of Tsinghua University(Science and Technology) ›› 2022, Vol. 62 ›› Issue (1) : 33-42. DOI: 10.16511/j.cnki.qhdxxb.2021.25.010

SPECIAL SECTION:DISASTER PREVENTION AND MITIGATION

Solid-gas products and reaction mechanism of pyrolysis of the sheath material of a typical flame-retardant low-voltage cable in substations during a fire

{{article.zuoZhe_EN}}

Author information +

History +

Abstract

Substations are key power system components, so substation fires can have serious consequences on system operations. In particular, more research is needed on the pyrolysis mechanism of cables in substations. There is little research on the chemical reactions and the gas products produced during pyrolysis of substation cables. The current study analyzed the pyrolysis kinetics, solid-gas product characteristics and reaction mechanism of the sheath material of a typical flame-retardant low-voltage power cable (type ZRB-VV22-0.6/1.0 kV) in a substation in the absence of oxygen. Thermogravimetric (TG) experiments were used to investigate the pyrolysis of the sheath material in a nitrogen atmosphere. The experiments showed that the pyrolysis can be divided into two major stages with activation energies of 145.17 and 241.71 kJ/mol for the two stages based on the Friedman, FWO and KAS methods. A field scanning electron microscope and an X-ray energy spectrometer (EDS) were used to analyze the elemental mass fractions of the raw material before pyrolysis and the residue after pyrolysis. The carbon mass fraction decreased due to volatilization of the carbon in the sheath. Ca, Mg and Si were not volatilized but remained in the residue with significantly greater mass fractions. Cl and O were partially volatilized with somewhat higher mass fractions in the residue. The volatilization of Cl infers the existence of HCl in the gas products. The use of Py-GC/MS to quantify the volatile products showed that the products of the first pyrolysis stage (<623 K) are mainly HCl and benzene. When the pyrolysis temperature rises up to 773 K, the products contain polycyclic aromatic hydrocarbons and benzene series. The main pyrolysis process is attributed to the pyrolysis of the PVC in the sheath material. Therefore, the main products are similar to PVC pyrolysis. The HCl yield was 0.077 g/g and the benzene yield was 0.266 g/g while the benzene series yields were relatively low.

Key words

fire / cable sheath / thermogravimetric analysis / element scanning / pyrolysis gas chrogams-mass spectrometry (Py-GC/MS)

Cite this article

EndNote

Ris (Procite)

Bibtex

Download Citations

ZHANG Jiaqing, GUO Yi, FENG Rui, LI Kaiyuan, HUANG Yubiao, SHANG Fengju. Solid-gas products and reaction mechanism of pyrolysis of the sheath material of a typical flame-retardant low-voltage cable in substations during a fire[J]. Journal of Tsinghua University(Science and Technology). 2022, 62(1): 33-42 https://doi.org/10.16511/j.cnki.qhdxxb.2021.25.010

References

[1] REN S J, SUN Q H. The law of insulation failure of ZR-VV cables under the circumstances of different thermal environments[J]. Procedia Engineering, 2016, 135:363-368.
[2] COURTY L, GARO J P. External heating of electrical cables and auto-ignition investigation[J]. Journal of Hazardous Materials, 2017, 321:528-536.
[3] WITKOWSKI A, GIRARDIN B, FÖRSTH M, et al. Development of an anaerobic pyrolysis model for fire retardant cable sheathing materials[J]. Polymer Degradation and Stability, 2015, 113:208-217.
[4] SURESH S S, MOHANTY S, NAYAK S K. Composition analysis and characterization of waste polyvinyl chloride (PVC) recovered from data cables[J]. Waste Management, 2017, 60:100-111.
[5] 林月娟, 徐严平, 陈耀文. 低真空条件下SEM/EDS对激光打印文字墨粉的鉴别[J]. 汕头大学学报(自然科学版), 2010, 25(4):75-80. LIN Y J, XU Y P, CHEN Y W. Identification of laser printer toners with SEM/EDS under the low vacuum level condition[J]. Journal of Shantou University (Natural Science), 2010, 25(4):75-80. (in Chinese)
[6] SUN W, YOU F, LI P, et al. Pyrolysis properties and kinetics of typical liquid oils in wind turbine nacelle[J]. Procedia Engineering, 2018, 211:668-673.
[7] MATALA A, HOSTIKKA S. Pyrolysis modelling of PVC cable materials[J]. Fire Safety Science-Proceedings of the Tenth International Symposium, 2011, 10:917-930.
[8] WANG C J, LIU H R, ZHANG J Q, et al. Thermal degradation of flame-retarded high-voltage cable sheath and insulation via TG-FTIR[J]. Journal of Analytical and Applied Pyrolysis, 2018, 134:167-175.
[9] WANG Z, WANG J. Comparative thermal decomposition characteristics and fire behaviors of commercial cables[J]. Journal of Thermal Analysis and Calorimetry, 2020. DOI:10.1007/s10973-020-10051-z.
[10] MUN S Y, HWANG C H. Experimental and numerical studies on major pyrolysis properties of flame retardant PVC cables composed of multiple materials[J]. Materials (Basel), 2020, 13(7):1712.
[11] MA W C, RAJPUT G, PAN M H, et al. Pyrolysis of typical MSW components by Py-GC/MS and TG-FTIR[J]. Fuel, 2019, 251:693-708.
[12] ZHOU J J, LIU G J, WANG S B, et al. TG-FTIR and Py-GC/MS study of the pyrolysis mechanism and composition of volatiles from flash pyrolysis of PVC[J]. Journal of the Energy Institute, 2020, 93(6):2362-2370.
[13] MIRANDA R, YANG J, ROU C, et al. Vacuum pyrolysis of PVC I. Kinetic study[J]. Polymer Degradation and Stability, 1999, 64(1):127-144.
[14] 王强, 王静, 曹亚丽, 等. 气相色谱-质谱法研究聚氯乙烯的热裂解行为[J]. 塑料科技, 2012, 40(5):93-95. WANG Q, WANG J, CAO Y L, et al. Research on the thermal pyrolytic behaviour of PVC through pyrolysis-gas chromatography-mass spectrometry[J]. Plastics Science and Technology, 2012, 40(5):93-95. (in Chinese)
[15] 马燕, 王强, 高晶, 等. 裂解气相色谱-质谱法研究聚氯乙烯树脂的热降解[J]. 化学试剂, 2009, 31(11):910-912. MA Y, WANG Q, GAO J, et al. Study on thermal decomposition of PVC by pyrolysis GC/MS[J]. Chemical Reagents, 2009, 31(11):910-912. (in Chinese)
[16] 郭子东. 典型核电电缆火灾危险性的热解实验研究[J]. 消防科学与技术, 2018, 37(5):602-604, 632. GUO Z D. Pyrolysis experiment of fire hazard of a typical nuclear power cable[J]. Fire Science and Technology, 2018, 37(5):602-604, 632. (in Chinese)
[17] CHEN R Y, LU S X, ZHANG Y, et al. Pyrolysis study of waste cable hose with thermogravimetry/Fourier transform infrared/mass spectrometry analysis[J]. Energy Conversion and Management, 2017, 153:83-92.
[18] FRIEDMAN H L. Kinetics of thermal degradation of char-forming plastics from thermogravimetry. application to a phenolic plastic[J]. Journal of Polymer Science Part C:Polymer Symposia, 1964, 6(1):183-195.
[19] OZAWA T. A new method of analyzing thermogravimetric data[J]. Bulletin of the Chemical Society of Japan, 1965, 38(11):1881-1886.
[20] FLYNN J H. The isoconversional method for determination of energy of activation at constant heating rates corrections for the doyle approximation[J]. Journal of Thermal Analysis, 1983, 27(1):95-102.
[21] LIM A C R, CHIN B L F, JAWAD Z A, et al. Kinetic analysis of rice husk pyrolysis using kissinger-akahira-sunose (KAS) method[J]. Procedia Engineering, 2016, 148:1247-1251.
[22] KISSINGER H E. Variation of peak temperature with heating rate in differential thermal analysis[J]. Journal of Research of the National Bureau of Standards, 1956, 57(4):217-221.
[23] MA Z Q, CHEN D Y, GU J, et al. Determination of pyrolysis characteristics and kinetics of palm kernel shell using TGA-FTIR and model-free integral methods[J]. Energy Conversion and Management, 2015, 89:251-259.
[24] 李苗, 康洁, 王晓玢, 等. N-十六烷基马来酰胺酸根合镧(Ⅲ)对聚氯乙烯的热稳定机理[J]. 高分子材料科学与工程, 2019, 35(11):88-100, 108. LI M, KANG J, WANG X F, et al. Heat stabilizing mechanism of complexes of lanthanum (Ⅲ) with N-hexadecyl maleamic acid radical for polyvinyl chloride[J]. Polymer Materials Science & Engineering, 2019, 35(11):88-100, 108. (in Chinese)
[25] 孙庆雷, 时新刚, 林云良, 等. 聚氯乙烯的热解特性和热解动力学研究[J]. 燃料化学学报, 2007, 35(4):497-500. SUN Q L, SHI X G, LIN Y L, et al. Pyrolysis of polyvinyl chloride and its kinetics analysis[J]. Journal of Fuel Chemistry and Technology, 2007, 35(4):497-500. (in Chinese)
[26] 赵艳萍, 刘申友, 张和平, 等. 聚氯乙烯电缆绝缘材料热解机理与动力学参数研究[J]. 消防科学与技术, 2012, 31(4):329-332. ZHAO Y P, LIU S Y, ZHANG H P, et al. Thermal decomposition mechanism and kinetics parameters of the polyvinyl chloride cable insulation material[J]. Fire Science and Technology, 2012, 31(4):329-332. (in Chinese)
[27] 韩斌, 吴玉龙, 封伟, 等. 聚氯乙烯热解动力学的研究[C]//第六届全国环境催化与环境材料学术会议论文集. 成都, 中国:中国化学会, 2009:124-125. HAN B, WU Y L, FENG W, et al. Study on the kinetics of pyrolysis of PVC[C]//Proceedings of the 6th National Conference on Environmental Catalysis and Environmental Materials. Chengdu, China:Chinese Chemical Society, 2009:124-125. (in Chinese)