Structural imperfections in ring micro-electromechanical system (MEMS) gyroscopes lead to frequency splitting of the operating mode and axial deflection of the vibrations, which are some of the main factors affecting the performance. The mass distribution imperfections most strongly influence the fourth harmonic component. The angular position of this defect is determined from the frequency response characteristics at the detection electrodes of the ring structure which were analyzed theoretically in this study for various defect angles. A method is also given to calculate the intrinsic axial direction of the ring structure operating mode from the frequency response parameters. The accuracy of this method was verified against finite element calculations of the harmonic response of the ring structure with structural defects with the results showing that the intrinsic axial relative error is about 2%.
WANG Jin
,
CHEN Zhiyong
,
ZHANG Rong
. Calculation of the intrinsic axial direction of a ring MEMS gyroscope[J]. Journal of Tsinghua University(Science and Technology), 2020
, 60(1)
: 76
-81
.
DOI: 10.16511/j.cnki.qhdxxb.2019.21.027
[1] YOON S, PARK U, RHIM J, et al. Tactical grade MEMS vibrating ring gyroscope with high shock reliability[J]. Microelectronic Engineering, 2015, 142:22-29.
[2] ACAR C, ANDREI S, MEMS vibratory gyroscopes:Structural approaches to improve robustness[M]. Boston, MA:Springer USA, 2009.
[3] MEYER A D, ROZELLE D M. Milli-HRG inertial navigation system[C]//Proceedings of the Position Location and Navigation Symposium (PLANS), 2012 IEEE/ION, 2012:24-29.
[4] MENG M Y, ZHANG W D. Zhang. The design and simulation of vibratory ring gyroscope[J]. Key Engineering Materials, 2014, 609-610:1029-1032.
[5] 胡倩, 李青松, 周鑫, 等. 基于改进PSO算法的嵌套环式微陀螺结构优化设计[J]. 传感技术学报, 2018, 31(11):1695-1699. HU Q, LI Q S, ZHOU X, et al. Structural optimization design of disk resonator gyroscope based on an improved PSO algorithm[J]. Chinese Journal of Sensors and Actuators, 2018, 31(11):1695-1699. (in Chinese)
[6] 赵洪波, 任顺清, 霍帅军, 等. 开环位置激励半球谐振陀螺仪工作原理与误差分析[J]. 压电与声光, 2013, 35(1):51-58. ZHAO R B, REN S Q, HUO J, et al. Operating principle and error analysis for hemispherical resonator gyro under open-loop positional excitation mode[J]. Piezoelectric and Acousto-optic, 2013, 35(1):51-58. (in Chinese)
[7] 任顺清, 赵洪波. 半球谐振子密度分布不均匀对输出精度的影响[J]. 中国惯性技术学报, 2011, 19(3):364-368. REN S Q, ZHAO H B. Influence of density error of hemispherical resonator on output accuracy of gyro[J].Journal of Chinese Inertial Technology, 2011, 19(3):364-368. (in Chinese)
[8] SHATALOV M Y, JOUBERT S V, COETZEE C E. The influence of mass imperfections on the evolution of standing waves in slowly rotating spherical bodies[J]. Journal of Sound and Vibration, 2011, 330(1):127-135.
[9] 林珂, 贺海平, 李陟, 等. 半球谐振陀螺质量缺陷误差振动研究[J]. 压电与声光, 2015, 37(3):497-499. LIN K, HE H P, LI Z, et al. Study on mass defect error vibration of hemispherical resonator gyroscope[J]. Piezoelectric and Acousto-Optic, 2015, 37(3):497-499. (in Chinese)
[10] 王旭, 吴文启, 方针, 等. 力平衡模式下半球谐振陀螺正交误差控制[J]. 仪器仪表学报, 2012, 33(4):936-941 WANG X, WU W Q, FANG Z, et al. Quadrature drift control of hemispherical resonator gyro under force-to-rebalance mode[J]. Chinese Journal of Scientific Instrument, 2012, 33(4):936-94. (in Chinese)
[11] 马特维耶夫, 伦宁, 巴萨拉比. 固态波陀螺仪导航系统[M].马菊红,译.哈尔滨:哈尔滨工业大学出版社,2013. MАТВЕЕВ B A, ЛУНИН Б С, БАСАРАБ M A. Solid gyroscope navigation system[M]. MA J H, trans. Harbin:Harbin Institute of Technology Press, 2013. (in Chinese)
[12] 方针, 刘余波. 半球谐振陀螺的基础理论研究[J]. 导航定位与授时, 2017, 4(2):72-78. FANG Z, LIU Y B. Study of basic theories of hemispherical resonator gyros[J]. Navigation Positioning & Timing, 2017, 4(2):72-78. (in Chinese)
[13] 李巍, 金鑫, 任顺清. 半球谐振陀螺仪频率裂解及固有刚性轴的测试方法[J].传感技术学报, 2016, 29(3):338-342. LI W, JIN X, REN S Q. Measurement of frequency splitting and inherent rigidity shaft of hemispherical resonator gyro[J]. Chinese Journal of Sensors and Actuators, 2016, 29(3):338-342. (in Chinese)
[14] KIM W. Free non-linear vibration of a rotating thin ring with the in-plane and out-of-plane motions[J]. Journal of Sound and Vibration, 2002, 258(1):167-178.
[15] CHANG C O, CHANG G E, CHOU C S, et al. In-plane free vibration of a single-crystal silicon ring[J]. International Journal of Solids and Structures, 2008, 45(24):6114-6132.
[16] 李灿, 汪立新, 黄松涛, 等. HRG四位置谐振子振幅检测方法及误差分析[J]. 电光与控制, 2015, 22(9):83-86. LI C, WANG L X, HUANG S T, et al. A four-point based HRG resonator amplitude measurement method and the error analysis[J]. Electronics Optics and Control, 2015, 22(9):83-86. (in Chinese)
